|Preserved Bristol Siddeley Olympus Mk 301 Engine Change Unit (ECU) complete with ancillaries and bulkheads.|
|National origin||United Kingdom|
|Manufacturer||Bristol Aero Engines
Bristol Siddeley Engines Limited
Rolls-Royce Bristol Engine Division
|Major applications||Avro Vulcan
|Developed into||Rolls-Royce/Snecma Olympus 593|
The Rolls-Royce Olympus (originally the Bristol B.E.10 Olympus) was the world's first two-spool axial-flow turbojet aircraft engine, originally developed and produced by Bristol Aero Engines. First running in 1950, its initial use was as the powerplant of the Avro Vulcan V bomber. The design was further developed for supersonic performance as part of the BAC TSR-2 programme. Later it saw production as the Rolls-Royce/Snecma Olympus 593, the powerplant for Concorde SST. Versions of the engine were licenced to Curtiss-Wright in the USA as the TJ-32 or J67 (military designation) and the TJ-38 'Zephyr'. The Olympus was also developed with success as a marine and industrial gas turbine.
Bristol Aero Engines (formerly Bristol Engine Company) merged with Armstrong Siddeley Motors in 1959 to form Bristol Siddeley Engines Limited (BSEL) which in turn was taken over by Rolls-Royce in 1966.
As of 2012, the Olympus remains in service as both a marine and industrial gas turbine. It also powers the restored Avro Vulcan XH558.
At the end of World War II, the Bristol Engine Company’s major effort was the development of the Hercules and Centaurus radial piston engines. By the end of 1946, the company had only 10 hours of turbojet experience with a small experimental engine called the Phoebus which was the gas generator or core of the Proteus turboprop then in development. In early 1947, the parent Bristol Aeroplane Company submitted a proposal for a medium-range bomber to the same specification B.35/46 which led to the Avro Vulcan and Handley Page Victor. The Bristol design was the Type 172 and was to be powered by four or six Bristol engines of 9,000 lbf (40 kN) thrust.
The thrust required of the new engine, then designated B.E.10 (later Olympus), would initially be 9,000 lbf (40 kN) with growth potential to 12,000 lbf (53 kN). The pressure ratio would be an unheard of 9:1. To achieve this, the initial design used a low pressure (LP) axial compressor and a high pressure (HP) centrifugal compressor, each being driven by its own single-stage turbine. This two-spool design made the compression more manageable, enabled faster engine acceleration ("spool up"), and reduced surge. The design was progressively modified and the centrifugal HP compressor was replaced by an axial HP compressor. This reduced the diameter of the new engine to the design specification of 40 in (100 cm). The Bristol Type 172 was cancelled though development continued for the Avro Vulcan and other projects.
Initial Development 
The first engine, its development designation being BOl.1 (Bristol Olympus 1), had six LP compressor stages and eight HP stages, each driven by a single-stage turbine. The combustion system was novel in that ten connected flame tubes were housed within a cannular system: a hybrid of separate flame cans and a true annular system. Separate combustion cans would have exceeded the diameter beyond the design limit and a true annular system was considered too advanced.
The BOl.1 first ran in May 1950 and produced 9,140 lbf (40.7 kN) thrust. The next development was the BOl.1/2 which produced 9,500 lbf (42 kN) thrust in December 1950. Examples of the similar BOl.1/2A were constructed for US manufacturer Curtiss-Wright which had bought a licence for developing the engine as the TJ-32 or J67. The somewhat revised BOl.1/2B, ran in December 1951 producing 9,750 lbf (43.4 kN) thrust. The engine was by now ready for air testing and the first flight engines, designated Olympus Mk 99, were fitted into a Canberra WD952 which first flew with these engines derated to 8,000 lbf (36 kN) thrust in August 1952. In May 1953, this aircraft reached a world record altitude of 63,668 ft (19,406 m). (Fitted with more powerful Mk 102 engines, the Canberra increased the record to 65,876 ft (20,079 m) in August 1955.)
- Of all the early initial developments, BOl.2 to BOl.5 (the BOl.5 was never built), perhaps the most significant was the BOl.3. Even before the Vulcan first flew, the Olympus 3 was being suggested as the definitive powerplant for the aircraft. In the event, the 'original' Olympus was continuously developed for the Vulcan B1. The BOl.3 was described in 1957 as "a high-ended product intermediate between the Olympus 100 and 200 series."
- not built
- Olympus Mk 100
- (BOl.1/2B) Similar to Olympus Mk 99 rated at 9,250 lbf (41.1 kN) thrust for second Vulcan prototype VX777. First flew September 1953.[N 1]
- Olympus Mk 101
- (BOl.1/2C) Larger turbine, 11,000 lbf (49 kN) thrust for initial production Vulcan B1 aircraft. First flew (XA889) February 1955.
- Olympus Mk 102
- (BOl.11) Additional zero stage on LP compressor, 12,000 lbf (53 kN) thrust for later production Vulcan B1 aircraft.
- Olympus Mk 104
- (BOl.12) Designation for Olympus Mk 102 modified on overhaul with new turbine and burners, 13,000 lbf (58 kN) thrust initially, 13,500 lbf (60 kN) thrust on uprating, standard on Vulcan B1A.
- 'Olympus 106'
- Used to describe the development engine for the Olympus 200 (BOl.6). Possibly a corruption of BOl.6 (Olympus 6).
- Olympus Mk 97
- This early engine tested an early annular combustion chamber. It was test flown on Bristol's Avro Ashton test bed WB493.
- Olympus Mk 201
- (BOl.7) Uprated Olympus Mk 200. 17,000 lbf (76 kN) thrust. Initial Vulcan B2 aircraft.
- Olympus Mk 202
- Disputed. Either Olympus Mk 201 modified with rapid air starter, or Olympus Mk 201 with redesigned oil separator breathing system. This was the definitive '200 series' engine fitted to Vulcans not fitted with the Mk 301. The restored Vulcan XH558 is fitted with Olympus Mk 202 engines.
- 'Olympus Mk 203'
- Very occasional reference to this elusive mark of engine can be found in some official Air Publications relating to the Vulcan B2. It is also noted in a manufacturer's archived document dated circa 1960.
- Olympus Mk 301
- (BOl.21) Additional zero stage on LP compressor. 20,000 lbf (89 kN) thrust. Later Vulcan B2 aircraft plus nine earlier aircraft[N 2] retrofitted. Later derated to 18,000 lbf (80 kN) thrust. Restored to original rating for Operation Black Buck.
- Olympus 510 series
- With a thrust in the region of 15,000 lbf (67 kN) to 19,000 lbf (85 kN), the 510 series were civilianised versions of the BOl.6. A team was sent to Boeing at Seattle to promote the engine in 1956 but without success.
- Olympus 551
- The Olympus 551 'Zephyr' was a derated and lightened version of the BOl.6 and rated at 13,500 lbf (60 kN) thrust. The engine was the subject of a licence agreement between Bristol Aero Engines and the Curtiss-Wright Corporation - the engine being marketed in the USA as the Curtiss-Wright TJ-38 Zephyr. There were hopes to fit the Olympus 551 to the Avro Type 740 and Bristol Type 200 trijet airliners which did not progress beyond the project stage. Curtiss-Wright also failed to market the engine.
- The performance specification for TSR2 was issued in 1962. It was to be powered by two BSEL Olympus Mk 320 (BOl.22R) engines rated at 30,610 lbf (136.2 kN) with reheat at take-off. The engine was a cutting edge derivative of the Olympus Mk 301 with a Solar-type afterburner. The engine first ran in March 1961 and was test flown in February 1962 underslung Vulcan B1 XA894 and was demonstrated at the Farnborough Air Show in September. In December 1962 during a full power ground run at Filton, the engine blew up after an LP turbine failure, completely destroying its host Vulcan in the subsequent fire.
- On its first flight in September 1964 the engines of the TSR-2 were scarcely flightworthy being derated and cleared for one flight. Nevertheless, the risk was deemed acceptable in the political climate of the time. With new engines, the TSR-2 XR219 flew another 23 times before the project was cancelled in 1965.
- Olympus 593
- Concorde. The Olympus 593 project was started in 1964, using the TSR2's Olympus Mk 320 as a basis for development. BSEL and Snecma Moteurs of France were to share the project. Acquiring BSEL in 1966, Rolls-Royce continued as the British partner. The Rolls-Royce/Snecma Olympus 593 was a reheated version of the Olympus which powered the supersonic airliner
- Formerly Olympus 593. 28,100 lbf (125 kN) thrust.
- Flight test and prototype aircraft. 34,370 lbf (152.9 kN) thrust with reheat.
- Production. Annular combustion chamber to reduce smoke
- Last production. 38,075 lbf (169.37 kN) thrust with reheat.
- Curtiss-Wright TJ-32
- Examples of the BOl.1/2A were delivered to Curtiss-Wright in 1950. The engine was Americanised during 1951 and flew under a Boeing B-29 testbed as the TJ-32.
- Curtiss-Wright J67
- To meet a USAF demand for an engine in the 15000 lb thrust class, the engine was the subject of a development contract, redesigned and designated J67. Development was protracted and in 1955, the USAF announced that there would be no production contract for the present J67. Several aircraft had been intended to receive the J67 including the Convair F-102 Delta Dagger.
- Curtiss-Wright T47
- The T47 was an attempt to produce a turboprop based upon the J67.
- TJ-38 Zephyr
- See Olympus 551 (above).
Variant notes 
- Second-generation Engines
- The initial design of the second generation 'Olympus 6' began in 1952. This was a major redesign with five LP and seven HP compressor stages and a canullar combustor with eight interconected flame tubes. In spite of a much greater mass flow, the size and weight of the BOl.6 was little different to earlier models.
Rival manufacturers Rolls-Royce lobbied very hard to have its Conway engine installed in the Vulcan B2 to achieve commonality with the Victor B2. As a consequence, Bristols undertook to complete development using company funds and peg the price to that of its fully government-funded rival.
- Olympus Mk 200
- (BOl.6) 16,000 lbf (71 kN) thrust. First B2 (XH533) only.
- Civilianised Olympus
- Plans to civilianise the Olympus go back as far as 1953 with the unveiling of the Avro Atlantic airliner based upon the Vulcan. However, most of the civilian derivatives, except for supersonic airliners, were developed from the BOl.6.
- Thin-wing Javelin
- One project that got beyond the drawing board was a supersonic development of the Gloster Javelin, the P370, powered by two BOl.6, 7, or 7SR engines. The design evolved into the P376 with two BOl.21R engines rated at 28,500 lbf (127 kN) with reheat. Eighteen aircraft were ordered in 1955. The project was abandoned the following year.
- Afterburning Olympus
- As early as 1952, Bristols had considered the use of reheat, or afterburning, to augment the thrust of the Olympus. Initially, a system called Bristol Simplifed Reheat was devised which was tested on a Rolls-Royce Derwent V mounted in an Avro Lincoln. Later it was tested on an Orenda engine in Canada and on an Olympus Mk 100 in the Avro Ashton test bed. Fully variable reheat became possible after an agreement with the Solar Aircraft Company of San Diego which manufactured bench units for the Olympus Mks 101 and 102.
Proposed aircraft applications 
Over the years, the Olympus was proposed for numerous other applications including:
- C104 which led to the C105 Avro Arrow: BOl.3
- Avro 718: BOl.3
- Avro 739 to OR339 (the requirement that culminated in TSR2): BOl.21R
- Avro 740: 3 x Mk 551
- Avro 750: 2 x Mk 551
- Avro Vulcan Phase 6 (B3): BOl.23, a development of the Mk 301. BOl.21/2, Mk 301 modified with aft fan.
- Bristol T172: B.E.10
- Bristol T177
- Bristol T180
- Bristol T198: Mk 591. Early supersonic airliner design (132 seats). The engine was a civilianised BOl.22R.
- Bristol T201: Mk 551
- Bristol T202
- Bristol T204 to OR339: BOl.22SR (simplified reheat)
- Bristol T205: Mark 551
- Bristol T213
- Bristol T223: Mk 593. Later supersonic airliner design (100 seats). Engine as Mk 591 with zero stage LP compressor and cooled HP turbine.
- de Havilland design to OR339: BOl.14R, BOl.15R. Developed from BOl.6R.
- Handley Page HP98: Pathfinder variant of Victor.
- Handley Page Victor B1: Mk 104
- Handley Page Victor Phase 3
- Handley Page HP107
- Handley Page Pacific
- Hawker P.1121: BOl.21R
- Hawker P.1129 to OR339: BOl.15R
- General Dynamics RB-57F: Mk 701 developed from Mk 301.
- Gloster P492/3: Mk 591
- Republic F-105 Thunderchief: BOl.21 for possible sale to RAF.
- SAAB 36
- SAAB 37 Viggen
- Vickers VC10: Development of Mk 555 with aft fan.
Marine Propulsion 
The first marine Olympus was built for the German Navy. In 1962 BSEL was contracted to provide the gas-generator and Brown Boveri was contracted to provide a two-stage long-life marine power turbine. A test bed was built for extensive shore trials. Construction of the ship which was intended for gas-turbine power was abandoned. Test running of the next marine Olympus began in 1966. The power turbine was of a single stage operating at 5600 rpm utilising wide-chord blades. Beginning its sea trials in early 1968, the Turunmaa, a 700 ton corvette of the Finnish Navy was the first Olympus-powered warship to enter service, some six months before HMS Exmouth, the first British ship which had been refitted to trial the propulsion system for the Royal Navy.
The TM1 and TM2 variants comprised a power turbine baseplate carrying the turbine and the gas generator mountings, and differed significantly only in the construction of the power turbine structure, which was a steel casting on the TM1 and a fabrication on the TM2. All TM1 and TM2 installations were fitted with an A-rated gas generator, serial numbers 2013xx.
The TM3 comprised a similar power turbine baseplate plus a gas generator enclosure, an air intake enclosure, and many support services including ventilation and fire extinguishing systems. All TM3 installations were fitted with a B-rated gas generator, serial numbers 2017xx.
Olympus TM1 
23,200 shp (17,300 kW) nominal. Installed ratings quoted where known.
- Finnish Navy
- Turunmaa class corvettes — one Olympus, three diesel.
- Royal Navy
Olympus TM2 
23,200 shp (17,300 kW) nominal. Installed ratings quoted where known.
Olympus TM3 
28,000 shp (21,000 kW) nominal. Installed ratings quoted where known.
- Royal Navy
- Argentine Navy
- Royal Thai Navy
- French Navy
- Royal Netherlands Navy
- Japan Maritime Self Defense Force
Industrial Power Generation 
The Olympus entered service as a peak demand industrial power generator in 1962 when the Central Electricity Generating Board (CEGB) commissioned a single prototype installation at its Hams Hall power station. Power was provided by an Olympus 201 exhausting through a two stage turbine powering a Brush synchronous alternator providing 20 MW at 3000 rpm. By 1972, the CEGB had installed 42 Olympus generating sets. Olympus engines are also used to provide back up power in case of a loss of grid electrical power at some of Britain's nuclear power stations.
Many sets were exported and many found use on offshore platforms. By 1990, over 320 sets had been sold to 21 countries, many of which remain in service.
Exhibits on display 
- Bristol Aero Collection Kemble Airfield - Mk 104, 593B
- Imperial War Museum North, Manchester - Mk 101
- RAF Museum Cosford - Mk 320
- Gatwick Aviation Museum Charlwood Surrey - Two Mk 320
- Yorkshire Air Museum Elvington, North Yorkshire - Mk 593
- Montrose Air Station Heritage Centre - Bristol B.E.10
Specifications Olympus 101 
Data from The Operational Olympus Flight and Lecture Notes, Vulcan Bristol Aero Engine School
- Type: Axial flow two-spool turbojet
- Length: 152.2 in (387 cm)
- Diameter: 40 in (100 cm)
- Dry weight: 3,615 lb (1,640 kg)
- Compressor: Axial 6 LP pressure stages, 8 HP stages
- Combustors: Cannular 10 flame tubes
- Turbine: HP single stage, LP single stage
- Fuel type: AVTUR or AVTAG
See also 
- Related development
- Bristol Siddeley BS100 (Olympus core)
- Comparable engines
- Related lists
- Baxter 1990 pp 10-13
- Baxter 1990 pp 13,18
- Baxter 1990 p 13
- Baxter 1990 pp 16, 18
- Baxter 1990 p 18
- Baxter 1990 p 20
- Baxter 1990 pp 22,24
- Baxter 1990 p 32
- Baxter 1990 p 173
- Arrow Flight 25 October 1957 p 647
- Baxter 1990 p 42
- Baxter 1990 p 44
- MOS Air Fleet Record of Aircraft Movements
- Baxter 1990 p 46
- Pilots Notes AP 4505C—PN
- Bristol Olympus Flight 9 December 1955 p 876
- Blackman 2007 p 101
- Baxter 1990 p 33
- Baxter 1990 p 50
- Baxter 1990 p 66
- Air Publication 101B-1902-1A Vulcan B Mk.2 Aircraft Servicing Manual Cover 2, Sect 4, Chap 1, AL 86, Sept '72, Para 54A.
- PDF section 5.2.4 Engines.
- Archives of the National Archive, PA1716/5/11/3/5.
- Baxter 1990 p 58
- Bulman 2001 pp 149 & 150
- Aircrew Manual AP101B-1902-15 Prelim p 10
- Baxter 1990 p 70
- Aero Engines 1957 Flight 26 July 1957 p 114
- Baxter 1990 p 36
- Baxter 1990 pp 36-40
- Baxter 1990 pp 78, 80
- Baxter 1990 pp 80-86
- Baxter 1990 pp 96-100
- Baxter 1990 p 131
- Baxter 1990 p 135
- Baxter 1990 p 11
- Baxter 1990 p149
- Baxter 1990 p 153
- Baxter 1990 p 165
- Bristol Olympus Flight 9 December 1955 p 875
- Aero Engines 1954 Flight 9 April 1954 p 462
- Bulman 2001 p 146
- 16,000 lb Thrust Flight 15 February 1957 p 200
- Baxter 1990 p 40
- Baxter 1990 pp 28 & 172
- Baxter 1990 p 26
-  Avro Type List  Avro Heritage
- Baxter 1990 p 172
- Addendum to Avro Brochure IPB 104
- Wikipedia article quoting Berns, Lennart A36 - SAABs atombombare avslöjad, Flygrevyn issue #4, April 1991
-  Historien om Viggen  Protec 2005 No 4
- Baxter 1990 p 101
- Potts 2011 IRIS Alvand Light Frigate militaryfactory.com
- KD Rahmat quoting Conway's All the World's Fighting Ships 1947-1995
- Libyan frigate Dat Assawari quoting Conway's All the World's Fighting Ships 1947-1995
- Baxter 1990 p 107
- Type 42 guided missile destroyer naval-hazegray.org
- Baxter 1990 p 115
- Almirante Brown class military-today.com
- Niteroi class naviosbrasileiros.com.br
- FF Aradu (MEKO 360) class' harpoondatabases.com
- HTMS Makut Rajakumarn quoting Conway's All the World's Fighting Ships 1947-1995
- Baxter 1990 p 111
- Georges Leygues class destroyer quoting Miller, David; Chris Miller (1986). Modern Naval Combat. USA: Salamandar Books. pp. 100–101. ISBN 0-517-61350-6.
- Weilingen globalsecurity.org
- Kortenaer class frigate quoting Conway's All the World's Fighting Ships 1947-1995
- Jacob van Heemskerck class frigate quoting Conway's All the World's Fighting Ships 1947-1995
- Yubari class destroyer escort quoting Jane's Fighting Ships 2005-2006.
- Baxter 1990 pp 110-123
- Baxter, Alan. Olympus — the first forty years. Derby, UK: Rolls-Royce Heritage Trust, 1990. ISBN 978-0-9511710-9-7
- Blackman, Tony. Vulcan Test Pilot. London, UK: Grub Street, 2009. ISBN 978-1-906502-30-0
- Bullman, Craig. The Vulcan B.Mk2 from a Different Angle. Bishop-Auckland, UK: Pentland Books, 2001. ISBN 1-85821-899-3
- Hooker, Stanley. Not Much of an Engineer. Marlsborough, UK: Airlife Publishing, 2002. ISBN 978-1-85310-285-1
|Wikimedia Commons has media related to: Rolls-Royce Olympus|
- Rolls-Royce Heritage Trust
- Turbine Support image of Olympus power station
- enginehistory.org Good image of Mk 301
- Flight cutaway of BOl.1/2A